Role of oxygen and nitrogen in n-type microcrystalline silicon carbide grown by hot wire chemical vapor deposition
- 8 December 2016
- journal article
- research article
- Published by AIP Publishing in Journal of Applied Physics
- Vol. 120 (22)
- https://doi.org/10.1063/1.4971402
Abstract
N-type microcrystalline silicon carbide (μc-SiC:H(n)) deposited by hot wire chemical vapor deposition provides advantageous opto-electronic properties for window layer material in silicon-based thin-film solar cells and silicon heterojunction solar cells. So far, it is known that the dark conductivity (σd) increases with the increase in the crystallinity of μc-SiC:H(n)films. However, due to the fact that no active doping source is used, the mechanism of electrical transport in these films is still under debate. It is suggested that unintentional doping by atmospheric oxygen (O) or nitrogen (N) contamination plays an important role in the electrical transport. To investigate the impact of O and N, we incorporated O and N in μc-SiC:H(n) films and compared the influence on the microstructural, electronic, and optical properties. We discovered that, in addition to increasing the crystallinity, it is also possible to increase the σd by several orders of magnitude by increasing the O-concentration or the N-concentration in the films. Combining a high concentration of O and N, along with a high crystallinity in the film, we optimized the σd to a maximum of 5 S/cm.Keywords
This publication has 30 references indexed in Scilit:
- Microstructure of hydrogenated silicon carbide thin films prepared by chemical vapour deposition techniquesJournal of Non-Crystalline Solids, 2012
- Mass and bond density measurements for PECVD a-SiCx:H thin films using Fourier transform-infrared spectroscopyJournal of Non-Crystalline Solids, 2011
- Synthesis and spectroscopic properties of silver:dye composite nanoparticles with a double‐shell structurephysica status solidi (c), 2010
- Highly transparent microcrystalline silicon carbide grown with hot wire chemical vapor deposition as window layers in n-i-p microcrystalline silicon solar cellsApplied Physics Letters, 2007
- Characterization of Undoped, N- and P-Type Hydrogenated Nanocrystalline Silicon Carbide Films Deposited by Hot-Wire Chemical Vapor Deposition at Low TemperaturesJapanese Journal of Applied Physics, 2007
- Isolated oxygen defects in- and-SiC: A theoretical studyPhysical Review B, 2002
- Deep level centers in silicon carbide: A reviewSemiconductors, 1999
- A Significant Reduction of Impurity Contents in Hydrogenated Microcrystalline Silicon Films for Increased Grain Size and Reduced Defect DensityJapanese Journal of Applied Physics, 1998
- Electronic transportPublished by Cambridge University Press (CUP) ,1991
- Hydrogen Diffusion and Solubility in Silicon CarbideJournal of the American Ceramic Society, 1978