Iron Particle Size Effects for Direct Production of Lower Olefins from Synthesis Gas
Top Cited Papers
- 6 September 2012
- journal article
- Published by American Chemical Society (ACS) in Journal of the American Chemical Society
- Vol. 134 (39), 16207-16215
- https://doi.org/10.1021/ja304958u
Abstract
The Fischer–Tropsch synthesis of lower olefins (FTO) is an alternative process for the production of key chemical building blocks from non-petroleum-based sources such as natural gas, coal, or biomass. The influence of the iron carbide particle size of promoted and unpromoted carbon nanofiber supported catalysts on the conversion of synthesis gas has been investigated at 340–350 °C, H2/CO = 1, and pressures of 1 and 20 bar. The surface-specific activity (apparent TOF) based on the initial activity of unpromoted catalysts at 1 bar increased 6–8-fold when the average iron carbide size decreased from 7 to 2 nm, while methane and lower olefins selectivity were not affected. The same decrease in particle size for catalysts promoted by Na plus S resulted at 20 bar in a 2-fold increase of the apparent TOF based on initial activity which was mainly caused by a higher yield of methane for the smallest particles. Presumably, methane formation takes place at highly active low coordination sites residing at corners and edges, which are more abundant on small iron carbide particles. Lower olefins are produced at promoted (stepped) terrace sites that are available and active, quite independent of size. These results demonstrate that the iron carbide particle size plays a crucial role in the design of active and selective FTO catalysts.Keywords
This publication has 31 references indexed in Scilit:
- Fischer–Tropsch synthesis: Support and cobalt cluster size effects on kinetics over Co/Al2O3 and Co/SiO2 catalystsFuel, 2011
- Alumina-supported iron oxide nanoparticles as Fischer–Tropsch catalysts: Effect of particle size of iron oxideJournal of Molecular Catalysis A: Chemical, 2010
- Mars-van Krevelen-like Mechanism of CO Hydrogenation on an Iron Carbide SurfaceCatalysis Letters, 2009
- Fischer-Tropsch Synthesis: Catalyst activation of low alpha iron catalystCatalysis Today, 2009
- Complementary Structure Sensitive and Insensitive Catalytic RelationshipsAccounts of Chemical Research, 2008
- Spectroscopic and Transient Kinetic Studies of Site Requirements in Iron-Catalyzed Fischer−Tropsch SynthesisThe Journal of Physical Chemistry B, 2001
- The effect of sulfide ions on a precipitated iron Fischer–Tropsch catalystApplied Catalysis A: General, 1999
- Effects of preparation, dispersion, and extent of reduction on activity/selectivity properties of iron/alumina CO hydrogenation catalystsJournal of Catalysis, 1989
- Structure sensitivity of hydrocarbon synthesis from carbon monoxide and hydrogenThe Journal of Physical Chemistry, 1984
- Effects of dispersion on the activity and selectivity of alumina-supported ruthenium catalysts for carbon monoxide hydrogenationJournal of Catalysis, 1982