A Rapid Aflatoxin B1 ELISA: Development and Validation with Reduced Matrix Effects for Peanuts, Corn, Pistachio, and Soybeans
- 20 April 2004
- journal article
- research article
- Published by American Chemical Society (ACS) in Journal of Agricultural and Food Chemistry
- Vol. 52 (10), 2746-2755
- https://doi.org/10.1021/jf0354038
Abstract
Among the competitive ELISAs for aflatoxins that have been described, few have been adequately validated for reduced matrix effects. Using an aflatoxin B(1) (AFB(1))-specific polyclonal antibody (produced from AFB(1)-oxime conjugated to bovine serum albumin (BSA)) and AFB(1)- and AFB(2)-enzyme conjugates, four direct competitive ELISAs based on 96-microwell plates (two standard assays and two rapid assays) were developed, paying special attention to producing a robust assay relatively free of interferences for a range of agricultural products. The antibody was AFB(1)-specific, detecting only AFB(1) in a mixture of four aflatoxins (AFB(1), AFB(2), AFG(1), and AFG(2)), but showed significant cross-reaction with AFG(1) (57-61%) when an individual compound was tested. Standard assays (long assays) exhibited higher sensitivities than rapid assays (short assays) with IC(50) values of 12 +/- 1.5 and 9 +/- 1.5 microg/kg in sample (with 1 in 5 dilution of sample extract) for AFB(1) and AFB(2)-enzyme conjugates, respectively. These assays have narrower detection ranges (7.1-55.5 microg/kg in sample) and required dilution of sample extracts to overcome solvent and matrix interferences, making these assays less ideal as analytical methods. Rapid assays exhibited IC(50) values of 21.6 +/- 2.7 and 12 microg/kg in sample for AFB(1)- and AFB(2)-enzyme conjugates, respectively. These assays have ideally broader detection ranges (4.2-99.9 microg/kg in sample) and showed no methanol effects up to 80% with significantly reduced matrix interferences as a result of the shorter incubation times and increasing the amounts of enzyme conjugate used. Therefore, the rapid assays were formatted to perform without a need for extract dilution. The rapid assays can be completed within 15 min, potentially suitable for receival bays where quick decision-making to segregate low and high contamination is critical. Further validation using the rapid assay with AFB(1)-enzyme conjugate indicated relatively good recoveries of AFB(1) spiked in corn, peanuts, pistachio, and soybeans, which were free from significant matrix effects. It can be concluded that this rapid assay would be suitable for monitoring aflatoxin AFB(1) at current legal maximum residue limits of 10 microg/kg in food such as corn, peanuts, pistachio, and soybeans.This publication has 10 references indexed in Scilit:
- Standardisation of mycotoxin sampling procedures: an urgent necessityFood Control, 2003
- How to establish international limits for mycotoxins in food and feed?Food Control, 2003
- Direct and indirect competitive monoclonal antibody-based ELISA of Aflatoxin B1 in groundnutMycotoxin Research, 1993
- Anomalous aflatoxin B1recoveries from whole peanuts and brazil nuts measured by enzyme‐linked immunosorbent assayFood and Agricultural Immunology, 1991
- ELISA determination of aflatoxin levels in whole nutsFood and Agricultural Immunology, 1990
- Production and characterization of aflatoxin B2 oximinoacetateJournal of Agricultural and Food Chemistry, 1989
- Production and characterization of antibodies cross-reactive with major aflatoxinsCellular and Molecular Life Sciences, 1989
- An ELISA method for the rapid and simple determination of aflatoxin in human serumFood Additives & Contaminants, 1988
- Production and characterization of a monoclonal antibody to aflatoxin B2Journal of Agricultural and Food Chemistry, 1988
- Base substitution mutations induced by metabolically activated aflatoxin B1.Proceedings of the National Academy of Sciences of the United States of America, 1983