Distinct Behaviors between Gypsum and Silica Scaling in Membrane Distillation
- 7 January 2020
- journal article
- research article
- Published by American Chemical Society (ACS) in Environmental Science & Technology
- Vol. 54 (1), 568-576
- https://doi.org/10.1021/acs.est.9b06023
Abstract
Mineral scaling constrains membrane distillation (MD) and limits its application in treating hypersaline wastewater. Addressing this challenge requires enhanced fundamental understanding of the scaling phenomenon. However, MD scaling with different types of scalants may have distinctive mechanisms and consequences which have not been systematically investigated in the literature. In this work, we compared gypsum and silica scaling in MD and demonstrated that gypsum scaling caused earlier water flux decline and induced membrane wetting that was not observed in silica scaling. Microscopic imaging and elemental mapping revealed contrasting scale morphology and distribution for gypsum and silica, respectively. Notably, while gypsum crystals grew both on the membrane surface and deep in the membrane matrix, silica only formed on the membrane surface in the form of a relatively thin film composed of connected submicrometer silica particles. We attribute the intrusion of gypsum into membrane pores to the crystallization pressure as a result of rapid, oriented crystal growth, which leads to pore deformation and the subsequent membrane wetting. In contrast, the silica scale layer was formed via polymerization of silicic acid and gelation of silica particles, which were less intrusive and had a milder effect on membrane pore structure. This hypothesis was supported by the result of tensile testing, which showed that the MD membrane was significantly weakened by gypsum scaling. The fact that different scaling mechanisms could yield different consequences on membrane performance provides valuable insights for the future development of cost-effective strategies for scaling control.Funding Information
- Division of Graduate Education (1445197)
- Bureau of Reclamation (R18AC00108)
- Division of Chemical, Bioengineering, Environmental, and Transport Systems (1705048)
- College of Engineering, Colorado State University
This publication has 61 references indexed in Scilit:
- Trade-off in membrane distillation with monolithic omniphobic membranesNature Communications, 2019
- Potential and implemented membrane-based technologies for the treatment and reuse of flowback and produced water from shale gas and oil plays: A reviewDesalination, 2019
- Membrane distillation at the water-energy nexus: limits, opportunities, and challengesEnergy & Environmental Science, 2018
- Membrane distillation research & implementation: Lessons from the past five decadesSeparation and Purification Technology, 2017
- Nanophotonics-enabled solar membrane distillation for off-grid water purificationProceedings of the National Academy of Sciences of the United States of America, 2017
- Fouling in direct contact membrane distillation of produced water from unconventional gas extractionJournal of Membrane Science, 2017
- The Global Rise of Zero Liquid Discharge for Wastewater Management: Drivers, Technologies, and Future DirectionsEnvironmental Science & Technology, 2016
- Desalination and Reuse of High-Salinity Shale Gas Produced Water: Drivers, Technologies, and Future DirectionsEnvironmental Science & Technology, 2013
- Membrane distillation: A comprehensive reviewDesalination, 2012
- Membrane distillationJournal of Membrane Science, 1997