Filtration Performance of NIOSH-Approved N95 and P100 Filtering Facepiece Respirators Against 4 to 30 Nanometer-Size Nanoparticles
- 15 July 2008
- journal article
- research article
- Published by Taylor & Francis Ltd in Journal of Occupational and Environmental Hygiene
- Vol. 5 (9), 556-564
- https://doi.org/10.1080/15459620802275387
Abstract
This study investigated the filtration performance of NIOSH-approved N95 and P100 filtering facepiece respirators (FFR) against six different monodisperse silver aerosol particles in the range of 4–30 nm diameter. A particle test system was developed and standardized for measuring the penetration of monodisperse silver particles. For respirator testing, five models of N95 and two models of P100 filtering facepiece respirators were challenged with monodisperse silver aerosol particles of 4, 8, 12, 16, 20, and 30 nm at 85 L/min flow rate and percentage penetrations were measured. Consistent with single-fiber filtration theory, N95 and P100 respirators challenged with silver monodisperse particles showed a decrease in percentage penetration with a decrease in particle diameter down to 4 nm. Penetrations less than 1 particle/30 min for 4–8 nm particles for one P100 respirator model, and 4–12 nm particles for the other P100 model, were observed. Experiments were also carried out with larger than 20 nm monodisperse NaCl particles using a TSI 3160 Fractional Efficiency Tester. NaCl aerosol penetration levels of 20 nm and 30 nm (overlapping sizes) particles were compared with silver aerosols of the same sizes by a three-way ANOVA analysis. A significant (p < 0.001) difference between NaCl and silver aerosol penetration levels was obtained after adjusting for particle sizes and manufacturers. A significant (p = 0.001) interaction with manufacturers indicated the difference in NaCl, and silver aerosol penetrations were not the same across manufacturers. The two aerosols had the same effect across 20 nm and 30 nm sizes as shown by the absence of any significant (p = 0.163) interaction with particle sizes. In the case of P100 FFRs, a significant (p < 0.001) difference between NaCl and silver aerosol (20 nm and 30 nm) penetrations was observed for both respirator models tested. The filtration data for 4–30 nm monodisperse particles supports previous studies that indicate NIOSH-approved air-purifying respirators provide expected levels of filtration protection against nanoparticles.Keywords
This publication has 20 references indexed in Scilit:
- What Does Respirator Certification Tell Us About Filtration of Ultrafine Particles?Journal of Occupational and Environmental Hygiene, 2008
- Do N95 respirators provide 95% protection level against airborne viruses, and how adequate are surgical masks?American Journal of Infection Control, 2006
- Manikin-Based Performance Evaluation of N95 Filtering-Facepiece Respirators Challenged with NanoparticlesAnnals of Occupational Hygiene, 2005
- Airborne Nanostructured Particles and Occupational HealthJournal of Nanoparticle Research, 2005
- Respiratory Protection Provided by N95 Filtering Facepiece Respirators Against Airborne Dust and Microorganisms in Agricultural FarmsJournal of Occupational and Environmental Hygiene, 2005
- Respiratory protection against bioaerosols: Literature review and research needsAmerican Journal of Infection Control, 2004
- Respiratory Protection Against Mycobacterium tuberculosis: Quantitative Fit Test Outcomes for Five Type N95 Filtering-Facepiece RespiratorsJournal of Occupational and Environmental Hygiene, 2004
- Electrostatic Respirator Filter Media: Filter Efficiency and Most Penetrating Particle Size EffectsApplied Occupational and Environmental Hygiene, 2000
- Tuberculosis control through respirator wear: Perforance of National Institute for Occupational Safety and Health-regulated respiratorsAmerican Journal of Infection Control, 1998
- Performance of N95 Respirators: Filtration Efficiency for Airborne Microbial and Inert ParticlesAihaj Journal, 1998