Experimental Investigation of Unsteady Flow Phenomena in a Centrifugal Compressor Vaned Diffuser of Variable Geometry
- 1 October 1999
- journal article
- Published by ASME International in Journal of Turbomachinery
- Vol. 121 (4), 763-771
- https://doi.org/10.1115/1.2836730
Abstract
The behavior of vaned radial diffusers is generally considered to be due to the flow phenomena in the vaneless and the semi-vaned space in the diffuser inlet region. Even considering unsteady aspects, the adjacent diffuser channel is regarded as less important. The flat wedge vaned diffuser of the centrifugal compressor stage investigated allows an independent continuous adjustment of the diffuser vane angle and the radial gap between impeller outlet and diffuser vane inlet, so that information about the importance of these geometric parameters can be obtained. The time-dependent pressure distribution on the diffuser front wall and on the suction and pressure surfaces of the diffuser vanes reveal that in the semi-vaned space mainly the region near the vane suction side is influenced by the unsteady impeller-diffuser interaction. Downstream in the diffuser channel the unsteadiness does not decay. Here, pressure fluctuations are appearing that are distinctly higher than the pressure fluctuations in the vaneless space. An estimation of the influence of the unsteadiness on the operating performance of the centrifugal compressor stage is made by measurements at choke and surge limit for different diffuser geometries.Keywords
This publication has 11 references indexed in Scilit:
- Aerodynamics of a Centrifugal Compressor Impeller With Transonic Inlet ConditionsPublished by ASME International ,1995
- Experimental Investigation of Rotor-Stator Interaction in a Centrifugal Pump With Several Vaned DiffusersJournal of Turbomachinery, 1990
- A Discussion of the Factors Affecting Surge in Centrifugal CompressorsJournal of Engineering for Gas Turbines and Power, 1985
- A Consideration Concerning Stall and Surge Limitations Within Centrifugal CompressorsJournal of Engineering for Power, 1982
- A Study on Centrifugal Impeller and Diffuser FlowJournal of Engineering for Power, 1981
- A Study of Diffuser/Rotor Interaction in a Centrifugal CompressorJournal of Mechanical Engineering Science, 1981
- Instantaneous Measurements in the Jet-Wake Discharge Flow of a Centrifugal Compressor ImpellerJournal of Engineering for Power, 1975
- Losses in Vaneless Diffusers of Centrifugal Compressors and Pumps: Analysis, Experiment, and DesignJournal of Engineering for Power, 1966
- Rotating Wakes in Vaneless DiffusersJournal of Basic Engineering, 1960
- Optimum Design of Straight-Walled DiffusersJournal of Basic Engineering, 1959