Drop formation and breakup of low viscosity elastic fluids: Effects of molecular weight and concentration
Top Cited Papers
- 1 April 2006
- journal article
- research article
- Published by AIP Publishing in Physics of Fluids
- Vol. 18 (4), 043101
- https://doi.org/10.1063/1.2190469
Abstract
The dynamics of drop formation and pinch-off have been investigated for a series of low viscosity elastic fluids possessing similar shear viscosities, but differing substantially in elastic properties. On initial approach to the pinch region, the viscoelastic fluids all exhibit the same global necking behavior that is observed for a Newtonian fluid of equivalent shear viscosity. For these low viscosity dilute polymer solutions, inertial and capillary forces form the dominant balance in this potential flow regime, with the viscous force being negligible. The approach to the pinch point, which corresponds to the point of rupture for a Newtonian fluid, is extremely rapid in such solutions, with the sudden increase in curvature producing very large extension rates at this location. In this region the polymer molecules are significantly extended, causing a localized increase in the elastic stresses, which grow to balance the capillary pressure. This prevents the necked fluid from breaking off, as would occur in the equivalent Newtonian fluid. Alternatively, a cylindrical filament forms in which elastic stresses and capillary pressure balance, and the radius decreases exponentially with time. A -dimensional finitely extensible nonlinear elastic dumbbell theory incorporating inertial, capillary, and elastic stresses is able to capture the basic features of the experimental observations. Before the critical “pinch time” , an inertial-capillary balance leads to the expected -power scaling of the minimum radius with time: . However, the diverging deformation rate results in large molecular deformations and rapid crossover to an elastocapillary balance for times . In this region, the filament radius decreases exponentially with time where is the characteristic time constant of the polymer molecules. Measurements of the relaxation times of polyethylene oxide solutions of varying concentrations and molecular weights obtained from high speed imaging of the rate of change of filament radius are significantly higher than the relaxation times estimated from Rouse-Zimm theory, even though the solutions are within the dilute concentration region as determined using intrinsic viscosity measurements. The effective relaxation times exhibit the expected scaling with molecular weight but with an additional dependence on the concentration of the polymer in solution. This is consistent with the expectation that the polymer molecules are in fact highly extended during the approach to the pinch region (i.e., prior to the elastocapillary filament thinning regime) and subsequently as the filament is formed they are further extended by filament stretching at a constant rate until full extension of the polymer coil is achieved. In this highly extended state, intermolecular interactions become significant, producing relaxation times far above theoretical predictions for dilute polymer solutions under equilibrium conditions.
Keywords
This publication has 49 references indexed in Scilit:
- On the evolution and rupture of filaments in Giesekus and FENE modelsJournal of Non-Newtonian Fluid Mechanics, 2004
- Viscoelastic potential flow analysis of capillary instabilityJournal of Non-Newtonian Fluid Mechanics, 2003
- Drop formation dynamics of constant low-viscosity, elastic fluidsJournal of Non-Newtonian Fluid Mechanics, 2002
- How to extract the Newtonian viscosity from capillary breakup measurements in a filament rheometerJournal of Rheology, 2000
- The effects of polymer concentration and molecular weight on the breakup of laminar capillary jetsJournal of Non-Newtonian Fluid Mechanics, 1998
- An experimental study of dynamics of drop formationPhysics of Fluids, 1995
- Rheological characterization of the time and strain dependence for polyisobutylene solutionsJournal of Non-Newtonian Fluid Mechanics, 1994
- The break-up of fluids in an extensional flow fieldJournal of Non-Newtonian Fluid Mechanics, 1992
- Nonlinear analysis of the surface tension driven breakup of viscoelastic filamentsJournal of Non-Newtonian Fluid Mechanics, 1986
- II. On dropsProceedings of the Royal Society of London, 1864