Improving the Nutritional Quality of Microwave-vacuum Dried Strawberries: A Preliminary Study
- 1 February 2006
- journal article
- research article
- Published by SAGE Publications in Food Science and Technology International
- Vol. 12 (1), 67-75
- https://doi.org/10.1177/1082013206062136
Abstract
Microwave-vacuum drying is an up-to-date technique for the conservation of fruits and vegetables, resulting in products with improved texture and colour. In order to evaluate the effects on the content of ascorbic acid, anthocyanins and phenolic compounds, and antioxidant capacity, three strawberry varieties were subjected to microwave-vacuum (MV) drying combined with convective pre- and post-drying, convective drying, and freeze-drying. The MV drying procedure comprised immersion in a pretreatment bath, pre-drying in a belt dryer to a moisture load of approx 45 g/100 g dry matter, and microwave treatment at 4 kPa for 8 min, leading to products with 5 g/100 g moisture. During post-drying, the moisture content was further reduced to approx 2 g/100 g. Convective drying and MV drying decreased the content of ascorbic acid to approx 40% of the initial value, phenolic compounds to approx 35%, and the antioxidative capacity to approx 60%. No reduction was observed in freeze-dried strawberries. Bypassing the pre-treatment bath, extending residence time in the pre-dryer to reduce temperature peaks, and reducing MV treatment time increased the recovery of ascorbic acid to approx 65%. Phenolic compounds remained stable, and the reduction of the antioxidative capacity was limited to 10% – 25%. Except ascorbic acid, the residual concentration of nutritionally relevant compounds after improving the processing conditions was close to the values as observed for freeze-dried products.Keywords
This publication has 38 references indexed in Scilit:
- Antioxidants, Low Molecular Weight Carbohydrates, and Total Antioxidant Capacity in Strawberries (Fragaria × ananassa): Effects of Cultivar, Ripening, and StorageJournal of Agricultural and Food Chemistry, 2004
- Cocoa Has More Phenolic Phytochemicals and a Higher Antioxidant Capacity than Teas and Red WineJournal of Agricultural and Food Chemistry, 2003
- Energy Consumption, Density, and Rehydration Rate of Vacuum Microwave‐ and Hot‐Air Convection‐ Dehydrated TomatoesJournal of Food Science, 2002
- EXPERIMENTAL STUDY ON DRYING OF CHILLI IN A COMBINED MICROWAVE-VACUUM-ROTARY DRUM DRYERDrying Technology, 2002
- COMBINED OSMOTIC AND MICROWAVE DRYING OF STRAWBERRIESDrying Technology, 1999
- Protective Effect of Broccoli, Onion, Carrot, and Licorice Extracts against Cytotoxicity of N-Nitrosamines Evaluated by 3-(4,5-Dimethylthiazol-2-yl)-2,5-diphenyltetrazolium Bromide AssayJournal of Agricultural and Food Chemistry, 1998
- MICROWAVE VACUUM DRYING KINETICS OF SOME FRUITSDrying Technology, 1997
- MICROWAVE-VACUUM DRYING OF CRANBERRIES: PART II. QUALITY EVALUATIONJournal of Food Processing and Preservation, 1996
- The air drying behaviour of fresh and osmotically dehydrated banana slicesInternational Journal of Food Science & Technology, 1996
- Influence of sous vide processing, steaming and boiling on vitamin retention and sensory quality in broccoli floretsZeitschrift für Lebensmittel-Untersuchung und Forschung, 1993