Performance and pressure distribution changes in a centrifugal pump under two-phase flow
- 1 May 1998
- journal article
- research article
- Published by SAGE Publications in Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy
- Vol. 212 (3), 165-171
- https://doi.org/10.1243/0957650981536835
Abstract
Pump performance characteristics change drastically under two-phase flow conditions from those of single-phase flow. This is due to a change in flow characteristics in the impeller. Owing to a positive pressure gradient the air bubble moves more slowly than the water in the impeller channel, but in the suction surface region of the impeller inlet, where a negative pressure gradient prevails, the bubbles move more quickly than the water. Thus, in the space just after this region the distributions of the void fraction obtained are considerably higher and uneven. The change in the pressure distribution owing to air admission is also particularly evident in the inlet region of the impeller. These changes bring about an alteration of the whole flow pattern in the impeller and also cause a drop in pump performance. The Reynolds-averaged Navier-Stokes equations for two-phase flow in a centrifugal pump impeller are solved using a finite volume method to obtain the pressure, velocities and void fraction respectively. Good agreement is achieved when the predicted results are compared with those measured experimentally within the range of bubbly flow conditions.Keywords
This publication has 9 references indexed in Scilit:
- Prediction of Pump Performance Under Air-Water Two-Phase Flow Based on a Bubbly Flow ModelJournal of Fluids Engineering, 1993
- Three-Dimensional Calculation of Air-Water Two-Phase Flow in Centrifugal Pump Impeller Based on a Bubbly Flow ModelJournal of Fluids Engineering, 1993
- Prediction of Three-Dimensional Steady Incompressible Flows Using Body-Fitted CoordinatesJournal of Fluids Engineering, 1993
- Characteristics of Centrifugal Pumps Handling Air-water Mixtures and Size of Air Bubbles in Pump ImpellersBulletin of JSME, 1985
- Performance Evaluation of Centrifugal Compressor Impellers Using Three-Dimensional Viscous Flow CalculationsJournal of Engineering for Gas Turbines and Power, 1984
- Pressure Distribution In a Centrifugal Impeller Handling Air-Water MixturesBulletin of JSME, 1983
- Detailed Flow Investigations Within a High-Speed Centrifugal Compressor ImpellerJournal of Fluids Engineering, 1976
- Numerical calculation of multiphase fluid flowJournal of Computational Physics, 1975
- Two-Dimensional Diffuser Performance With Subsonic, Two-Phase, Air–Water FlowJournal of Basic Engineering, 1972