Microfluidic pumps employing surface acoustic waves generated in ZnO thin films
- 15 January 2009
- journal article
- research article
- Published by AIP Publishing in Journal of Applied Physics
- Vol. 105 (2), 024508
- https://doi.org/10.1063/1.3068326
Abstract
ZnO thin film based surface acoustic wave (SAW) devices have been utilized to fabricate microfluidic pumps. The SAW devices were fabricated on nanocrystalline ZnO piezoelectric thin films deposited on Si substrates using rf magnetron sputtering and use a Sezawa wave mode for effective droplet motion. The as-deposited ZnO surface is hydrophilic, with a water contact angle of , which prevents droplet pumping. Therefore, the ZnO surface was coated using a self-assembled monolayer of octadecyltrichlorosilane which forms a hydrophobic surface with a water contact angle of . Liquid droplets between 0.5 and in volume were successfully pumped on the hydrophobic ZnO surface at velocities up to . Under acoustic pressure, the water droplet on an hydrophilic surface becomes deformed, and the asymmetry in the contact angle at the trailing and leading edges allow the force acting upon the droplet to be calculated. These forces, which increase with input voltage above a threshold level, are found to be in the range of . A pulsed rf signal has also been used to demonstrate precision manipulation of the liquid droplets. Furthermore, a SAW device structure is demonstrated in which the ZnO piezoelectric only exists under the input and output transducers. This structure still permits pumping, while avoiding direct contact between the piezoelectric material and the fluid. This is of particular importance for biological laboratory-on-a-chip applications.
Keywords
This publication has 43 references indexed in Scilit:
- Micropumps, microvalves, and micromixers within PCR microfluidic chips: Advances and trendsBiotechnology Advances, 2007
- Effect of Low-Surface-Tension Liquid on Pattern Collapse Analyzed by Observing Dynamical MeniscusJapanese Journal of Applied Physics, 2006
- RETRACTED: Recent progress in processing and properties of ZnOProgress in Materials Science, 2005
- Influence of the substrate on the structural properties of sputter-deposited ZnO filmsphysica status solidi (a), 2003
- Surface acoustic wave gas sensor of the sorption type sensitive to the thermal properties of gasesTechnical Physics Letters, 2002
- Physical and structural properties of ZnO sputtered filmsMaterials Letters, 2001
- Electrowetting-based actuation of liquid droplets for microfluidic applicationsApplied Physics Letters, 2000
- Charge Conveyance and Nonlinear Acoustoelectric Phenomena for Intense Surface Acoustic Waves on a Semiconductor Quantum WellPhysical Review Letters, 1999
- New Manipulator Based on Surface Acoustic Wave StreamingJapanese Journal of Applied Physics, 1998
- The motion of a mercury index in a capillary tubeProceedings of the Physical Society, 1938