State-of-Charge Estimation and State-of-Health Prediction of a Li-Ion Degraded Battery Based on an EKF Combined With a Per-Unit System
- 23 September 2011
- journal article
- research article
- Published by Institute of Electrical and Electronics Engineers (IEEE) in IEEE Transactions on Vehicular Technology
- Vol. 60 (9), 4249-4260
- https://doi.org/10.1109/tvt.2011.2168987
Abstract
This paper describes the application of an extended Kalman filter (EKF) combined with a per-unit (p.u.) system to the identification of suitable battery model parameters for the high-accuracy state-of-charge (SOC) estimation and state-of-health (SOH) prediction of a Li-Ion degraded battery. Variances in electrochemical characteristics among Li-Ion batteries caused by aging differences result in erroneous SOC estimation and SOH prediction when using the existing EKF algorithm. To apply the battery model parameters varied by the aging effect, based on the p.u. system, the absolute values of the parameters in the equivalent circuit model in addition to the discharging/charging voltage and current are converted into dimensionless values relative to a set of base value. The converted values are applied to dynamic and measurement models in the EKF algorithm. In particular, based on two methods such as direct current internal resistance measurement and the statistical analysis of voltage pattern, each diffusion resistance (RDiff) can be measured and used for offline and online SOC estimations, respectively. All SOC estimates are within ±5% of the values estimated by ampere-hour counting. Moreover, it is shown that RDiff is more sensitive than other model parameters under identical experimental conditions and, hence, implementable for SOH prediction.Keywords
This publication has 38 references indexed in Scilit:
- Recursive approximate weighted total least squares estimation of battery cell total capacityJournal of Power Sources, 2011
- Dynamic electric behavior and open-circuit-voltage modeling of LiFePO4-based lithium ion secondary batteriesJournal of Power Sources, 2011
- Optimization studies of carbon additives to negative active material for the purpose of extending the life of VRLA batteries in high-rate partial-state-of-charge operationJournal of Power Sources, 2010
- A novel combined battery model for state-of-charge estimation in lead-acid batteries based on extended Kalman filter for hybrid electric vehicle applicationsJournal of Power Sources, 2007
- State-of-the-art of battery state-of-charge determinationMeasurement Science and Technology, 2005
- Characterizing aging effects of lithium ion batteries by impedance spectroscopyElectrochimica Acta, 2005
- Calendar life performance of pouch lithium-ion cellsJournal of Power Sources, 2004
- Extended Kalman filtering for battery management systems of LiPB-based HEV battery packsJournal of Power Sources, 2004
- Extended Kalman filtering for battery management systems of LiPB-based HEV battery packsJournal of Power Sources, 2004
- Fuzzy-controlled Li-ion battery charge system with active state-of-charge controllerIEEE Transactions on Industrial Electronics, 2001