Unstable Transients Affecting Flow Assurance during Hydraulic Transportation of Granular Two-Phase Slurries
- 1 September 2021
- journal article
- research article
- Published by American Society of Civil Engineers (ASCE) in Journal of Hydraulic Engineering
- Vol. 147 (9), 04021029
- https://doi.org/10.1061/(asce)hy.1943-7900.0001913
Abstract
Hydraulic two-phase transport applied in the dredging, mining, and deep-sea mining industries involves the transportation of sand, gravel, polymetallic nodules, or other particulate tailings as a solids phase and water as a liquid phase. Regardless of the type or size of the granular material, the slurry flow is always subject to transient behavior. Most transient behavior can be attributed to the centrifugal pump as variations in pump pressure and mixture velocity over time, but transients can also be caused by microscopic slurry mechanisms, specifically the amplification of density waves in a pipeline. Density wave amplification in horizontal pipelines at mixture velocities just above the deposition limit velocity was reported and researched in the 1990s. New experiments showing a density wave amplification in a system with combined vertical and horizontal pipelines and at mixture velocities far above the deposition limit suggest that another type of density wave amplification mechanism exists. The newly proposed density wave amplification mechanism is hypothesized to be caused by a change in average particle velocity as the slurry flows from a vertical pipe into a horizontal pipe. Density waves that grow too large cause system blockages or possibly a failure of the pump drive. This article considers centrifugal pump–induced transients and density wave amplification effects separately and how these effects influence each other. Three case studies showing density wave amplification are analyzed, one from the literature and two from new data sets. Furthermore, the causes of these transients are discussed, and where possible, solutions are proposed to avoid these undesirable instabilities.Keywords
This publication has 17 references indexed in Scilit:
- Effect of pipe inclination on internal structure of settling slurry flow at and close to deposition limitPowder Technology, 2018
- Effect of pipe inclination on the deposition velocity of settling slurriesThe Canadian Journal of Chemical Engineering, 2016
- Numerical prediction of dispersed turbulent liquid–solid flows in vertical pipesJournal of Hydraulic Research, 2014
- Morphology and displacement of dunes in a closed-conduit flowPowder Technology, 2009
- Ripple formation on a particle bed sheared by a viscous liquid. Part 1. Steady flowJournal of Fluid Mechanics, 2006
- Phase distribution and turbulence structure for solid/fluid upflow in a pipeInternational Journal of Multiphase Flow, 1994
- Experimental Determination of Bed-Form StabilityAnnual Review of Earth and Planetary Sciences, 1991
- A convenient empirical equation for estimation of the Richardson-Zaki exponentChemical Engineering Science, 1987
- Velocity-Voidage Relationships for Fluidization and Sedimentation in Solid-Liquid SystemsIndustrial & Engineering Chemistry Process Design and Development, 1977
- The Formation of Sediment Ripples, Dunes, and AntidunesAnnual Review of Fluid Mechanics, 1969