Study of the suitable value of dead-time between control signals of transistors for a series-resonant inverter with phase-shift control in induction heating systems
Open Access
- 27 May 2021
- journal article
- Published by OU Scientific Route in EUREKA: Physics and Engineering
- No. 3,p. 60-70
- https://doi.org/10.21303/2461-4262.2021.001823
Abstract
Induction heating provides contactless, energy-efficient, accurate, and fast heating of electrically conductive materials. Due to its advantages, IH is increasingly used in different fields such as industry, medicine, and the household sector. High-frequency transistor converters for the induction heating system are often based on series-resonant inverters. This paper analyzes a phase-shift-controlled voltage-source series-resonant inverter for induction heating systems. Mathematical analysis was performed in order to obtain the expressions that describe the output current of the phase-shift-controlled series-resonant inverter in the steady-state mode. Based on the analysis and the obtained expressions of the output current, analytical expressions of the dead-time between the transistors’ control signals of the SRI are obtained. The analytical expressions for determining the value of the dead-time are obtained for two cases: 1) zero value of the phase-shift; 2) the phase shift is greater than zero. To verify the obtained analytical expressions of the output current, validation was performed in the MATLAB/Simulink environment by comparing the peak current values. The verification showed the high accuracy of the obtained expressions, the deviation between the calculated and simulated values of the peak current is less than 0.1 %. The made simplifications of the dead-time expressions also were verified by calculation, the deviation between the calculated values of the drain-to-source voltage at the end of the commutation and the expected value is no more than 3.6 %. The SRI prototype has been designed and implemented in order to validate the analytical and simulation resultsKeywords
This publication has 22 references indexed in Scilit:
- Dead time influence on operating modes of transistor resonant inverter with pulse frequency modulation (PFM)International Journal of Power Electronics and Drive Systems (IJPEDS), 2019
- A discrete-time controller for Phase Shift Controlled load-resonant inverter without PLLPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2014
- Shift phase power control in induction heating systems with voltage resonant inverterPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2014
- Analysis of Two Continuous Control Regions of Conventional Phase Shift and Transition Phase Shift for Induction Heating Inverter under ZVS and NON-ZVS OperationIEEE Transactions on Power Electronics, 2008
- Design of a 10 kW, 500 kHz phase-shift controlled series-resonant inverter for induction heatingPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2002
- Control system design and small-signal analysis of a phase-shift-controlled series-resonant inverter for induction heatingPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2002
- New induction heated fluid energy conversion processing appliance incorporating auto-tuning PID control-based PWM resonant IGBT inverter with sensorless power factor correctionPublished by Institute of Electrical and Electronics Engineers (IEEE) ,2002
- Half-bridge series resonant inverter for induction heating applications with load-adaptive PFM control strategyPublished by Institute of Electrical and Electronics Engineers (IEEE) ,1999
- Pulse-density-modulated power control of a 4 kW, 450 kHz voltage-source inverter for induction melting applicationsIEEE Transactions on Industry Applications, 1996
- New phase-shifted soft-switching PWM high-frequency series resonant inverters' topologies and their practical evaluationsPublished by Institution of Engineering and Technology (IET) ,1994